ShapeShapeauthorShapechevroncrossShapeShapeShapeGrouphamburgerhomeGroupmagnifyShapeShapeShaperssShape
Sponsor message
Now new in the US - Dietary diformates Made in Germany Learn more

Ethanol Byproduct Turned into Food Fit for a Pig

by 5m Editor
20 February 2009, at 8:26am

US - A relatively cheap ethanol byproduct mixed with an old nutritional standby might help pork producers cut feed costs.

Gary A. Apgar, an animal scientist at Southern Illinois University Carbondale, has been testing a blend of distillers' grains — the fat, minerals, vitamins and fiber remaining after corn’s starch becomes fuel — and soybeans, a traditional protein source for swine.

The combination turns out to be every bit as nutritious as soybean meal and, because grains cost less than beans, it's cheaper, too.

"Soy meal runs about $300 per ton and contains about 47.5 per cent crude protein, where distillers' grains cost about $125 per ton and contain 27 per cent crude protein," Apgar said.

"If for $250 you can get 54 per cent crude protein, it's much more economical."

Apgar's work is part of a larger project aimed at solving two problems facing the ethanol industry: factory emissions in newer plants that exceed US Environmental Protection Agency limits and the need to deal with the increased volume of byproducts that will result from expanded ethanol production.

Apgar's group, a consortium of private company representatives, university researchers and scientists from a national laboratory based in Peoria, is tinkering with the production process at a new ethanol plant in Wisconsin, hoping to cut emissions while turning the left-over grains into a more marketable livestock feed.

Newer plants generally use a dry mill process to produce ethanol, but the drying creates those pesky greenhouse gasses. Wet milling solves the emissions problem, but the grains left behind spoil more easily than dried distillers’ grains and are harder to ship, thus reducing their value.

So the researchers began looking at trade-offs. They theorized that by shutting off the drying process early for about 15 per cent of the residue, they could reduce emissions enough to meet EPA standards.

By adding soybeans to the semi-wet grains, compressing the two and forcing them through an extruder (a process which helps prevent spoilage), they hoped to create a feed with the higher nutritional value of wet grains plus the shelf life and handling ease of the dried variety.

But would this new feed provide an adequate mix of nutrients for pigs, which normally do not chow down on dried grains, much less wet ones? And would the extrusion process itself have any effect on the feed’s nutrients?

"Extrusion involves both pressure and heat," Apgar said.

"This reaction can cause carbohydrates and proteins to bind to each other. When they don’t break down, they're not available to the animal."

To test the feed's digestibility, Apgar analyzed feces and urine produced by pigs fed wet grains, pigs fed dried grains, pigs fed the extruded grains/soybean mix and those fed a grains/soy mix that hadn’t gone through the extruder. He also wanted to know how much of the feed’s nitrogen wound up outside the pigs. "Poor nitrogen digestion would say we had affected the metabolic process negatively," Apgar said.

"The pig couldn't use it, so he was just excreting it."

To get the data, Apgar used a system that allows collection of virtually all of the material passing through the last section of a pig's small intestine.

"Most systems only collect 40 percent of the sample that goes by — it's incomplete," he said.

Apgar found the mix performed better than he thought it would, proving significantly more digestible, in terms of the essential amino acids a pig needs, than the grains by themselves. While roughly two-thirds of that effect came from the soybean meal, the fact that wet grains cost around $50 per ton as compared to $125 for dry grains means the mixed feed would cost less than rations consisting solely of either dried grains or soybeans.

When it came to nitrogen, Apgar found that although extruded feed containing distillers' grains did lessen the amount of nitrogen the pig used, the excess tended to wind up in the faeces rather than the urine.

"That's not a bad thing because the effluent can be used in crop production (as fertilizer), where a high nitrogen content better matches corn production needs," Apgar said.

Apgar and a graduate student reported these results last summer during a national meeting of the American Society of Animal Science in Indianapolis.

"After the presentation, we had a line of extension agents and other researchers wanting to talk with us about the impact," Apgar said.

"This could give farmers a protein source that would allow them to maximize the inclusion rate of a low-cost ingredient when formulating their rations. On the industry side, it could reduce the environmental impact of ethanol production while enhancing the value of by-product production."

Sponsored content
Our Formi products fulfil tomorrow’s requirements today.

Formi NDF and the 3rd Generation acidifier Formi 3G have been formulated to replace the need for in-feed antibiotics, by ensuring a strong antibacterial impact against Gram negative and Gram positive bacteria.

The Formi product line, based on Addcon’s patented diformate technology ensures optimal efficiency, highest growth rates and maximum safety, which are key requirements in animal production worldwide – and are now available in the USA.

Learn more